环保采暖锅炉讲解取暖锅炉的安全操作规程
    2013-12-21 11:29:16  文章来源:http://www.jnlzsb.com

    一、值班人员必须遵守公司的各项规章制度,按时交接班,

    A, staff must abide by the regulations of the company, timely handover,

    爱护好公物。

    Take good care of public property.

    二、保持水箱正常水位,严禁缺水运行,水位低于液位计三分之一应及时补水。

    Two, to maintain the normal water level of the water tank, no running water, the water level is lower than the level of 1/3 should be timely replenishment.

    三、严格执行操作规程,杜绝违章操作。

    Three, the implementation of strict rules, put an end to the illegal operations.

    四、跟据燃烧情况调整上层炉门开度及引凤机调节门开度,下层炉门关闭。严禁超温运行,当炉水温度高于80度时应关闭引机,保持水泵运转循环,水温50度时开启引风机投煤升温运行。

    Four, according to the combustion adjustment of the upper door opening and Park machine regulating door opening, the lower door closed. No over temperature operation, when the water temperature is higher than 80 degrees should be shut down the machine, keep the pump operating cycle, the water temperature of 50 degrees when open cast coal heating operation of induced draft fan.

    五、上层炉门投煤,保持煤层10-15公分且煤层均匀布满炉排。

    Five, the upper door cast coal, coal and coal seam keeps 10-15 cm evenly covered with grate.

    六、每白班中午排污一次,时间一分钟。每班下班前炉灰必须清理干净,每周三、日中午除尘器清灰一次。每两小时各楼进出水总管处检查一次,并对温度、压力做好记录。

    Six, every day at noon emissions once a minute. Each class of the end of the ashes must be clean, every week three, noon dust once. Every two hours of water each floor duct check at once, and make a record of the temperature, pressure.

    七、风机启动前,应关闭调节门,等电机转速正常后,再逐步打开调节门,直至实用工况。每班检查风机轴承油位,保持油标二分之一。

    Seven, the fan before the start, should close the door, motor speed is normal, and then gradually open the door, until the practical condition. Each class check the fan bearing level, keeping 1/2 of the oil scale.

    八、做好锅炉运行记录(燃煤量,电流,温度)

    Eight, do a good job of boiler operation records (temperature coal consumption, current,)

    环保采暖锅炉http://www.jnlzsb.com/ 

<友情连结> 新利18luck jxf吉祥坊 云顶斗地主